Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 KOI ASIAN BISTRO 		License/Permit #
 BB223
Street Address
906 N CONVENT ST
City/State
 BOURBONNAIS, IL 		ZIP Code
 60914
No. of Risk Factor/Intervention Violations 3
No. of Repeat Risk Factor/Intervention Violations 0
Date 06/22/2021
Time In 11:00 AM
Time Out 12:55 PM
Permit Holder
ZHANG, MINGJAIN 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible X  

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35 X Approved thawing methods used    
36 X Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37 X Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39 X Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44 X Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47 X Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54 X Garbage & refuse properly disposed; facilities maintained    
55   Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: KOI ASIAN BISTRO Establishment #: BB223
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: CHLORINE 100 Heat: NA °F
CFPM Verification (name, ID#, expiration date):
JING LI
62080511931
06/01/2025

01/01/1900

01/01/1900

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
Green Peppers/Prep cooler 40.00°F Beef/Prep cooler 40.00°F Dumpling/Stand up cooler 41.00°F
Squid/Refrigerator 35.00°F Chicken/Walk-in cooler 36.00°F /Bar cooler 36.00°F
Tuna/Sushi display cooler 39.00°F Salmon/Sushi cooler 32.00°F /Chest freezer 1 0.00°F
/Chest freezer 2 0.00°F /Chest freezer 3 0.00°F Soup/Soup warmer 170.00°F
Sauce/Prep table 190.00°F Chicken/Prep table 200.00°F Eel/Sushi oven 147.00°F
Rice/Sushi rice warmer 147.00°F    

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
10 PF 5-205.11 (A): (A) A HANDWASHING SINK shall be maintained so that it is accessible at all times for EMPLOYEE use.
The hand washing sink at the server station had a bucket of sanitizer solution inside, preventing hand washing. COS
10 PF 6-301.12 (A-D): Each HANDWASHING SINK or group of adjacent HANDWASHING SINKS shall be provided with: (A) Individual, disposable towels; (B) A continuous towel system that supplies the user with a clean towel; or (C) A heated-air hand drying device; or (D) A hand drying device that employs an air-knife system that delivers high velocity, pressurized air at ambient temperatures.
The hand washing sink in the kitchen did not have paper towels. COS
15 P 3-302.11 (A) (2): (A) FOOD shall be protected from cross contamination by:   (2) Except when combined as ingredients, separating types of raw animal FOODS from each other such as beef, FISH, lamb, pork, and POULTRY during storage, preparation, holding, and display by: (a) Using separate EQUIPMENT for each type, or (b) Arranging each type of FOOD in EQUIPMENT so that cross contamination of one type with another is prevented, and (c) Preparing each type of FOOD at different times or in separate areas.
Raw meat products were stored improperly in the sushi freezer. Store all products in order of their cooking temperature: ready to eat products on top, followed by shell eggs, seafood, whole cuts of meat, ground meats, and poultry at the bottom. - (Correct By: Jun 25, 2021)
35 C 3-501.13: TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be thawed: (A) Under refrigeration that maintains the FOOD temperature at 5°C (41°F) or less; or (B) Completely submerged under running water: (1) At a water temperature of 21°C (70°F) or below, (2) With sufficient water velocity to agitate and float off loose particles in an overflow, and (3) For a period of time that does not allow thawed portions of READY-TO-EAT FOOD to rise above 5°C (41°F), or (4) For a period of time that does not allow thawed portions of a raw animal FOOD requiring cooking as specified under ¶ 3-401.11(A) or (B) to be above 5°C (41°F), for more than 4 hours including: (a) The time the FOOD is exposed to the running water and the time needed for preparation for cooking, or (b) The time it takes under refrigeration to lower the FOOD temperature to 5°C (41°F); (C) As part of a cooking process if the FOOD that is frozen is: (1) Cooked as specified under ¶3-401.11(A) or (B) or § 3-401.12, or (2) Thawed in a microwave oven and immediately transferred to conventional cooking EQUIPMENT, with no interruption in the process; or (D) Using any procedure if a portion of frozen READY-TO-EAT FOOD is thawed and prepared for immediate service in response to an individual CONSUMER'S order. (E) REDUCED OXYGEN PACKAGED FISH that bears a label indicating that it is to be kept frozen until time of use shall be removed from the reduced oxygen environment: (1) Prior to its thawing under refrigeration as specified in(A) of this section; or (2) Prior to, or Immediately upon completion of, its thawing using procedures specified in (B) of this section.
Tuna was thawed still in reduced oxygen packaging. When thawing seafood, remove from the reduced oxygen packaging immediately before thawing and maintain by the next routine inspection.
36 C 4-204.112 (B-C): (B) Except as specified in¶(C) of this section, cold or hot holding EQUIPMENT used for TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be designed to include and shall be equipped with at least one integral or permanently affixed TEMPERATURE MEASURING DEVICE that is located to allow easy viewing of the device's temperature display. 4-204.112 Temperature Measuring Devices.(C) Paragraph (B) of this section does not apply to EQUIPMENTfor which the placement of a TEMPERATURE MEASURING DEVICE is not a practical means for measuring the ambient air surrounding the FOOD because of the design, type, and use of the EQUIPMENT, such as calrod units, heat lamps, cold plates, bainmaries, steam tables, insulated FOOD transport containers, and salad bars.
The stand-up refrigerator/freezer in the kitchen and the sushi display cooler did not have thermometers. Provide a thermometer for each cold holding unit and maintain by the next routine inspection.
37 C 3-302.12: Except for containers holding FOOD that can be readily and unmistakably recognized such as dry pasta, working containers holding FOOD or FOOD ingredients that are removed from their original packages for use in the FOOD ESTABLISHMENT, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be identified with the common name of the FOOD.
Many food items throughout the establishment were removed from their original packaging and were not labeled with their common name. Label all products with the common name and maintain by the next routine inspection.
39 C 3-305.11 (A) (B) (C): (A) Except as specified in ¶¶ (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location; (2) Where it is not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor. (B) FOOD in packages and working containers may be stored less than 15 cm (6 inches) above the floor on case lot handling EQUIPMENT as specified under § 4-204.122. (C) Pressurized BEVERAGE containers, cased FOOD in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.
Observed the following products stored improperly: 1)Uncovered items on shelves near the prep area without covers, 2)Bag of onions and opened bag of rice stored on the floor near the back door. Store all items covered and 6" above the floor and maintain by the next routine inspection.
44 C 4-904.11 (B): (B) Knives, forks, and spoons that are not prewrapped shall be presented so that only the handles are touched by EMPLOYEES and by CONSUMERS if CONSUMER self-service is provided.
Silverware at the server station was stored in an unorganized fashion, allowing for contamination of the food contact surface. Store all utensils so that only the handle will be touched and maintain by the next routine inspection.
47 C 4-501.11 (B): (B) EQUIPMENT components such as doors, seals, hinges, fasteners, and kick plates shall be kept intact, tight, and adjusted in accordance with manufacturer's specifications.
The seals of the prep cooler are torn and hanging loose. Repair these and maintain by the next routine inspection.
47 C 4-501.11 (A): (A) EQUIPMENT shall be maintained in a state of repair and condition that meets the requirements specified under Parts 4-1 and 4-2.
Shelves in the walk-in cooler have a buildup of rust. Clean or replace these and maintain by the next routine inspection.
49 C 4-602.13: NonFOOD-CONTACT SURFACES of EQUIPMENT shall be cleaned at a frequency necessary to preclude accumulation of soil residues.
The following non-food contact surfaces are in need of cleaning: 1)Fryer door and interior, 2)Walk-in cooler shelving, 3)Lid of the exterior used oil storage unit. Clean and maintain by the next routine inspection.
54 C 5-501.113: Receptacles and waste handling units for REFUSE, recyclables, and returnables shall be kept covered: (A)Inside the FOOD ESTABLISHMENT if the receptacles and units: (1)Contain FOOD residue and are not in continuous use; or (2)After they are filled; and (B)With tight-fitting lids or doors if kept outside the FOOD ESTABLISHMENT.
The lid of the dumpster was open. Close this lid and maintain by the next routine inspection.
Inspection Comments   UPDATE CFPM AND FOOD HANDLER CERTIFICATIONS BY THE NEXT ROUTINE INSPECTION.
HACCP Topic: PROPER COMPLETION AND RETENTION OF SUSHI PH HACCP RECORDS.
 

Person In Charge

  JING LI 		 

Date:

  06/22/2021
 

Inspector

  DANA JAMES 		 

Follow-up:  Yes   No   Follow-up Date:

06/25/2021